Air Intake Throttle Position High
What does DD-3482-0 mean?
The DD-3482-0 (Detroit Diesel DD Series) diesel fault code means: Air Intake Throttle Position High. This is a moderate severity code.
Common Symptoms
- Check Engine Light / Amber Warning Lamp illuminated
- Rough idle or misfire
- Noticeable power loss under load
Probable Causes (Ranked by Likelihood)
- Soot-packed intake throttle Very Likely
- Failed throttle actuator Likely
- Signal wire short to voltage Possible
Step-by-Step Diagnostic Procedure
Remove intake throttle and clean; common on EPA10/GHG14.
Perform throttle calibration via DDDL.
Replace throttle body if actuator is stuck.
Frequently Asked Questions
What is Detroit Diesel fault code DD-3482-0?
Detroit Diesel fault DD-3482-0 (SPN 3482 FMI 0) indicates: Air Intake Throttle Position High. It is a moderate-severity fault and is commonly seen on DD13/DD15/DD16 engines in Freightliner and Western Star chassis.
Can I drive my Freightliner or Western Star with fault DD-3482-0?
It depends on severity. Critical and serious faults trigger derate or engine shutdown — do not continue driving. Moderate faults usually allow continued operation short-term but schedule repair to prevent cascading aftertreatment damage.
How much does it cost to fix Detroit Diesel fault DD-3482-0?
Typical repair cost is $500-$2,200. Sensor/harness fixes fall at the low end; turbo actuator, injector, aftertreatment component, or head gasket repairs fall at the high end. Detroit DDDL software and sometimes factory parameter reset are required for proper reset.